Tags

Type your tag names separated by a space and hit enter

PdO/PdO2 functionalized ZnO : Pd films for lower operating temperature H2 gas sensing.
Nanoscale 2018; 10(29):14107-14127N

Abstract

Noble metals and their oxide nano-clusters are considered to be the most promising candidates for fabricating advanced H2 gas sensors. Through this work, we propose a novel strategy to grow and modulate the density of PdO/PdO2 nanoparticles uniformly on nanostructured Pd-doped ZnO (ZnO : Pd) films by a one-step solution approach followed by thermal annealing at 650 °C, and thus to detect ppm-level H2 gas in a selective manner. The gas sensing properties of such hybridized materials showed that the PdO-functionalized ZnO samples offer significantly improved H2 gas sensing properties in an operating temperature range of 25-200 °C. The deposition of ZnO : Pd films via a simple synthesis from chemical solutions (SCS) approach with an aqueous bath (at relatively low temperatures, <95 °C) is reported. Furthermore, the functionalization of palladium oxide nanoclusters by a simple but highly effective approach on ZnO : Pd film surfaces was performed and is reported here for the first time. The morphological, structural, vibrational, optical, chemical, and electronic properties were studied in detail and the mixed phases of palladium oxide nanoclusters on the ZnO surface were found. Sensor studies of the ZnO : Pd samples (in the range of 25-350 °C operating temperature) showed good selectivity to H2 gas, especially in the range of higher temperatures (>150 °C, up to 350 °C); however, the PdO/PdO2 mixed phases of the nanocluster-modified surface ZnO : Pd films showed a much better selectivity to H2 gas, even at a lower operating temperature, in the range of 25-150 °C. For such PdO-functionalized ZnO : Pd films, even at room temperature, a gas response of ∼12.7 to 1000 ppm of H2 gas was obtained, without response to any other reducing gases or tested vapors. The large recovery time of the samples at room temperatures (>500 s) can be drastically reduced by applying higher bias voltages. Furthermore, we propose and discuss the gas sensing mechanism for these structures in detail. Our study demonstrates that surface functionalization with PdO/PdO2 mixed phase nanoclusters-nanoparticles (NPs) is much more effective than only the Pd doping of nanostructured ZnO films for selective sensing applications. This approach will pave a new way for the controlled functionalization of PdO/PdO2 nanoclusters on ZnO : Pd surfaces to the exact detection of highly explosive H2 gas under various atmospheres by using solid state gas sensors.

Authors+Show Affiliations

Institute for Materials Science - Functional Nano Materials, Faculty of Engineering, Kiel University, Kaiserstraβe 2, D-24143 Kiel, Germany. ollu@tf.uni-kiel.de ra@tf.uni-kiel.de and Department of Microelectronics and Biomedical Engineering, Technical University of Moldova, 168 Stefan cel Mare Av., MD-2004 Chisinau, Republic of Moldova. oleg.lupan@mib.utm.md and Chimie ParisTech, PSL Research University, CNRS, Institut de Recherche de Chimie Paris (IRCP-UMR8247), 11 rue Pierre et Marie Curie 75231, F-75005 Paris, France.Department of Microelectronics and Biomedical Engineering, Technical University of Moldova, 168 Stefan cel Mare Av., MD-2004 Chisinau, Republic of Moldova. oleg.lupan@mib.utm.md.Institute for Materials Science - Functional Nano Materials, Faculty of Engineering, Kiel University, Kaiserstraβe 2, D-24143 Kiel, Germany. ollu@tf.uni-kiel.de ra@tf.uni-kiel.de.Institute for Materials Science - Synthesis and Real Structure, Faculty of Engineering, Christian-Albrechts-University of Kiel, Kaiserstraβe 2, D-24143 Kiel, Germany.Institute for Materials Science - Functional Nano Materials, Faculty of Engineering, Kiel University, Kaiserstraβe 2, D-24143 Kiel, Germany. ollu@tf.uni-kiel.de ra@tf.uni-kiel.de.Chimie ParisTech, PSL Research University, CNRS, Institut de Recherche de Chimie Paris (IRCP-UMR8247), 11 rue Pierre et Marie Curie 75231, F-75005 Paris, France.Chimie ParisTech, PSL Research University, CNRS, Institut de Recherche de Chimie Paris (IRCP-UMR8247), 11 rue Pierre et Marie Curie 75231, F-75005 Paris, France.Chimie ParisTech, PSL Research University, CNRS, Institut de Recherche de Chimie Paris (IRCP-UMR8247), 11 rue Pierre et Marie Curie 75231, F-75005 Paris, France.Institute for Materials Science - Synthesis and Real Structure, Faculty of Engineering, Christian-Albrechts-University of Kiel, Kaiserstraβe 2, D-24143 Kiel, Germany.Institute for Materials Science - Chair for Multicomponent Materials, Faculty of Engineering, Christian-Albrechts-University of Kiel, Kaiserstraβe 2, D-24143 Kiel, Germany.Institute for Materials Science - Functional Nano Materials, Faculty of Engineering, Kiel University, Kaiserstraβe 2, D-24143 Kiel, Germany. ollu@tf.uni-kiel.de ra@tf.uni-kiel.de.

Pub Type(s)

Journal Article

Language

eng

PubMed ID

29999088

Citation

Lupan, Oleg, et al. "PdO/PdO2 Functionalized ZnO : Pd Films for Lower Operating Temperature H2 Gas Sensing." Nanoscale, vol. 10, no. 29, 2018, pp. 14107-14127.
Lupan O, Postica V, Hoppe M, et al. PdO/PdO2 functionalized ZnO : Pd films for lower operating temperature H2 gas sensing. Nanoscale. 2018;10(29):14107-14127.
Lupan, O., Postica, V., Hoppe, M., Wolff, N., Polonskyi, O., Pauporté, T., ... Adelung, R. (2018). PdO/PdO2 functionalized ZnO : Pd films for lower operating temperature H2 gas sensing. Nanoscale, 10(29), pp. 14107-14127. doi:10.1039/c8nr03260b.
Lupan O, et al. PdO/PdO2 Functionalized ZnO : Pd Films for Lower Operating Temperature H2 Gas Sensing. Nanoscale. 2018 Aug 7;10(29):14107-14127. PubMed PMID: 29999088.
* Article titles in AMA citation format should be in sentence-case
TY - JOUR T1 - PdO/PdO2 functionalized ZnO : Pd films for lower operating temperature H2 gas sensing. AU - Lupan,Oleg, AU - Postica,Vasile, AU - Hoppe,Mathias, AU - Wolff,Niklas, AU - Polonskyi,Oleksandr, AU - Pauporté,Thierry, AU - Viana,Bruno, AU - Majérus,Odile, AU - Kienle,Lorenz, AU - Faupel,Franz, AU - Adelung,Rainer, Y1 - 2018/07/12/ PY - 2018/7/13/pubmed PY - 2018/7/13/medline PY - 2018/7/13/entrez SP - 14107 EP - 14127 JF - Nanoscale JO - Nanoscale VL - 10 IS - 29 N2 - Noble metals and their oxide nano-clusters are considered to be the most promising candidates for fabricating advanced H2 gas sensors. Through this work, we propose a novel strategy to grow and modulate the density of PdO/PdO2 nanoparticles uniformly on nanostructured Pd-doped ZnO (ZnO : Pd) films by a one-step solution approach followed by thermal annealing at 650 °C, and thus to detect ppm-level H2 gas in a selective manner. The gas sensing properties of such hybridized materials showed that the PdO-functionalized ZnO samples offer significantly improved H2 gas sensing properties in an operating temperature range of 25-200 °C. The deposition of ZnO : Pd films via a simple synthesis from chemical solutions (SCS) approach with an aqueous bath (at relatively low temperatures, <95 °C) is reported. Furthermore, the functionalization of palladium oxide nanoclusters by a simple but highly effective approach on ZnO : Pd film surfaces was performed and is reported here for the first time. The morphological, structural, vibrational, optical, chemical, and electronic properties were studied in detail and the mixed phases of palladium oxide nanoclusters on the ZnO surface were found. Sensor studies of the ZnO : Pd samples (in the range of 25-350 °C operating temperature) showed good selectivity to H2 gas, especially in the range of higher temperatures (>150 °C, up to 350 °C); however, the PdO/PdO2 mixed phases of the nanocluster-modified surface ZnO : Pd films showed a much better selectivity to H2 gas, even at a lower operating temperature, in the range of 25-150 °C. For such PdO-functionalized ZnO : Pd films, even at room temperature, a gas response of ∼12.7 to 1000 ppm of H2 gas was obtained, without response to any other reducing gases or tested vapors. The large recovery time of the samples at room temperatures (>500 s) can be drastically reduced by applying higher bias voltages. Furthermore, we propose and discuss the gas sensing mechanism for these structures in detail. Our study demonstrates that surface functionalization with PdO/PdO2 mixed phase nanoclusters-nanoparticles (NPs) is much more effective than only the Pd doping of nanostructured ZnO films for selective sensing applications. This approach will pave a new way for the controlled functionalization of PdO/PdO2 nanoclusters on ZnO : Pd surfaces to the exact detection of highly explosive H2 gas under various atmospheres by using solid state gas sensors. SN - 2040-3372 UR - https://www.unboundmedicine.com/medline/citation/29999088/PdO/PdO2_functionalized_ZnO_:_Pd_films_for_lower_operating_temperature_H2_gas_sensing_ L2 - https://doi.org/10.1039/c8nr03260b DB - PRIME DP - Unbound Medicine ER -